![](parsexml(1)_files/CAC5AF0P.jpg)
|
|
|
1 |
- |
+VE battery cable |
2 |
- |
Battery |
3 |
- |
Clamp |
4 |
- |
Transit relay |
5 |
- |
-VE battery cable |
GENERAL
The battery is located between the bulkhead and the secondary
bulkhead, in a protective box, on the passenger side. It sits in a tray and is
secured with clamp plates and bolts.
The battery terminal posts allow for
the battery cables to be connected with clamp type connections. The battery
positive terminal uses a pyrotechnic attachment, which detaches the battery
cable in the event of a crash of a severity to trigger the airbags.
Air Bag and Safety Belt Pretensioner Supplemental Restraint System
(SRS) (501-20B Supplemental Restraint System)
All models are
fitted with Delphi lead-calcium, maintenance free battery. Each battery is
similar in construction with the battery rating varying according to
application. There are two different battery sizes:
- H7 - All petrol variants H8 - TdV6
The battery uses 'calcium expanded'
technology, which has both positive and negative plates with grids expanded from
a strip lead-calcium alloy.
The battery is semi-sealed. Each casing has a
vent to allow for thermal expansion and to vent oxygen and hydrogen gases, which
are produced under certain charging conditions.
The battery incorporates
an integral, temperature compensated hydrometer to provide a visual indication
of the relative density and level of the electrolyte. The indicator shows
different colours to show battery condition as follows:
- GREEN – shows that the battery is charged and in a serviceable condition
- DARK (turning to black) – shows that the battery is in a low state of
charge and requires recharging
- CLEAR or YELLOW – the battery is no longer serviceable and must be
replaced.
If the battery shows CLEAR or YELLOW the battery has an
internal fault. Do not attempt to charge or jump-start the vehicle with the
battery in this condition.
When removing the battery, ensure that the
alarm is disarmed and that the ignition is switched off. Always disconnect the
negative terminal first and then the positive terminal. When refitting the
battery, always fit the positive terminal first followed by the negative
terminal.
If the battery requires recharging, always use an approved
constant current charger, designed for lead-calcium batteries. DO NOT use a fast
charger, permanent damage to the battery may occur.
Delivery Mode
The vehicle is fitted with a transit relay. This is a
disposable device and NOT for use by the customer. This relay fits in
series with the battery and ground; it disconnects the battery from the
vehicle's ground and thus eliminates quiescent current during delivery. The
relay must be removed before delivery to the customer.